part ii
. chap. i. s. vi.). Later still it was adopted by the vassal princes of the empire. This gave rise to the name "despotats" as applied to these tributary states, which survived the break-up of the empire in the independent "despotats" of Epirus, Cyprus, Trebizond, &c. Under Ottoman rule the title was preserved by the despots of Servia and of the Morea, &c. The early use of the term as a title of address for ecclesiastical dignitaries survives in its use in the Greek Church as the formal mode of addressing a bishop.
DES PRÉS, JOSQUIN (c. 1445-1521), also called DEPRÉS or DESPREZ, and by a latinized form of his name, JODOCUS PRATENSIS or A PRATO, French musical composer, was born, probably in Condé in the Hennegau, about 1445. He was a pupil of Ockenheim, and himself one of the most learned musicians of his time. In spite of his great fame, the accounts of his life are vague and the dates contradictory. Fétis contributed greatly towards elucidating the doubtful points in his _Biographie universelle_. In his early youth Josquin seems to have been a member of the choir of the collegiate church at St Quentin; when his voice changed he went (about 1455) to Ockenheim to take lessons in counterpoint; afterwards he again lived at his birthplace for some years, till Pope Sixtus IV. invited him to Rome to teach his art to the musicians of Italy, where musical knowledge at that time was at a low ebb. In Rome Des Prés lived till the death of his protector (1484), and it was there that many of his works were written. His reputation grew rapidly, and he was considered by his contemporaries to be the greatest master of his age. Luther, who was a good judge, is credited with the saying that "other musicians do with notes what they can, Josquin what he likes." The composer's journey to Rome marks in a manner the transference of the art from its Gallo-Belgian birthplace to Italy, which for the next two centuries remained the centre of the musical world. To Des Prés and his pupils Arcadelt, Mouton and others, much that is characteristic in modern music owes its rise, particularly in their influence upon Italian developments under Palestrina. After leaving Rome Des Prés went for a time to Ferrara, where the duke Hercules I. offered him a home; but before long he accepted an invitation of King Louis XII. of France to become the chief singer of the royal chapel. According to another account, he was for a time at least in the service of the emperor Maximilian I. The date of his death has by some writers been placed as early as 1501. But this is sufficiently disproved by the fact of one of his finest compositions, _A Dirge (Déploration) for Five Voices_, being written to commemorate the death of his master Ockenheim, which took place after 1512. The real date of Josquin's decease has since been settled as the 27th of August 1521. He was at that time a canon of the cathedral of Condé (see Victor Delzant's _Sépultures de Flandre_, No. 118).
The most complete list of his compositions--consisting of masses, motets, psalms and other pieces of sacred music--will be found in Fétis. The largest collection of his MS. works, containing no less than twenty masses, is in the possession of the papal chapel in Rome. In his lifetime Des Prés was honoured as an eminent composer, and the musicians of the 16th century are loud in his praise. During the 17th and 18th centuries his value was ignored, nor does his work appear in the collections of Martini and Paolucci. Burney was the first to recover him from oblivion, and Forkel continued the task of rehabilitation. Ambros furnishes the most exhaustive account of his achievements. An admirable account of Josquin's art, from the rare point of view of a modern critic who knows how to allow for modern difficulties, will be found in the article "Josquin," in Grove's _Dictionary of Music and Musicians_, new ed. vol. ii. The _Répertoire des chanteurs de St Gervais_ contains an excellent modern edition of Josquin's _Miserere_.
DESPRÈS, SUZANNE (1875- ), French actress, was born at Verdun, and trained at the Paris Conservatoire, where in 1897 she obtained the first prize for comedy, and the second for tragedy. She then became associated with, and subsequently married, Aurelien Lugné-Poë (b. 1870), the actor-manager, who had founded a new school of modern drama, _L'OEuvre_, and she had a brilliant success in several plays produced by him. In succeeding years she played at the Gymnase and at the Porte Saint-Martin, and in 1902 made her début at the Comédie Française, appearing in _Phèdre_ and other important parts.
DESRUES, ANTOINE FRANÇOIS (1744-1777), French poisoner, was born at Chartres in 1744, of humble parents. He went to Paris to seek his fortune, and started in business as a grocer. He was known as a man of great piety and devotion, and his business was reputed to be a flourishing one, but when, in 1773, he gave up his shop, his finances, owing to personal extravagance, were in a deplorable condition. Nevertheless he entered into negotiations with a Madame de la Mothe for the purchase from her of a country estate, and, when the time came for the payment of the purchase money, invited her to stay with him in Paris pending the transfer. While she was still his guest, he poisoned first her and then her son, a youth of sixteen. Then, having forged a receipt for the purchase money, he endeavoured to obtain possession of the property. But by this time the disappearance of Madame de la Mothe and her son had aroused suspicion. Desrues was arrested, the bodies of his victims were discovered, and the crime was brought home to him. He was tried, found guilty and condemned to be torn asunder alive and burned. The sentence was carried out (1777), Desrues repeating hypocritical protestations of his innocence to the last. The whole affair created a great sensation at the time, and as late as 1828 a dramatic version of it was performed in Paris.
DESSAIX, JOSEPH MARIE, COUNT (1764-1834), French general, was born at Thonon in Savoy on the 24th of September 1764. He studied medicine, took his degree at Turin, and then went to Paris, where in 1789 he joined the National Guard. In 1791 he tried without success to raise an _émeute_ in Savoy, in 1792 he organized the "Legion of the Allobroges," and in the following years he served at the siege of Toulon, in the Army of the Eastern Pyrenees, and in the Army of Italy. He was captured at Rivoli, but was soon exchanged. In the spring of 1798 Dessaix was elected a member of the Council of Five Hundred. He was one of the few in that body who opposed the _coup d'état_ of the 18th Brumaire (November 9, 1799). In 1803 he was promoted general of brigade, and soon afterwards commander of the Legion of Honour. He distinguished himself greatly at the battle of Wagram (1809), and was about this time promoted general of division and named grand officer of the Legion of Honour, and in 1810 was made a count. He took part in the expedition to Russia, and was twice wounded. For several months he was commandant of Berlin, and afterwards delivered the department of Mont Blanc from the Austrians. After the first restoration Dessaix held a command under the Bourbons. He nevertheless joined Napoleon in the Hundred Days, and in 1816 he was imprisoned for five months. The rest of his life was spent in retirement. He died on the 26th of October 1834.
See _Le Général Dessaix, sa vie politique et militaire_, by his nephew Joseph Dessaix (Paris, 1879).
DESSAU, a town of Germany, capital of the duchy of Anhalt, on the left bank of the Mulde, 2 m. from its confluence with the Elbe, 67 m. S.W. from Berlin and at the junction of lines to Cöthen and Zerbst. Pop. (1905) 55,134. Apart from the old quarter lying on the Mulde, the town is well built, is surrounded by pleasant gardens and contains many handsome streets and spacious squares. Among the latter is the Grosse Markt with a statue of Prince Leopold I. of Anhalt-Dessau, "the old Dessauer." Of the six churches, the Schlosskirche, adorned with paintings by Lucas Cranach, in one of which ("The Last Supper") are portraits of several reformers, is the most interesting. The ducal palace, standing in extensive grounds, contains a collection of historical curiosities and a gallery of pictures, which includes works by Cimabue, Lippi, Rubens, Titian and Van Dyck. Among other buildings are the town hall (built 1899-1900), the palace of the hereditary prince, the theatre, the administration offices, the law courts, the Amalienstift, with a picture gallery, several high-grade schools, a library of 30,000 volumes and an excellently appointed hospital. There are monuments to the philosopher Moses Mendelssohn (born here in 1729), to the poet Wilhelm Müller, father of Professor Max Müller, also a native of the place, to the emperor William I., and an obelisk commemorating the war of 1870-71. The industries of Dessau include the production of sugar, which is the chief manufacture, woollen, linen and cotton goods, carpets, hats, leather, tobacco and musical instruments. There is also a considerable trade in corn and garden produce. In the environs are the ducal villas of Georgium and Luisium, the gardens of which, as well as those of the neighbouring town of Wörlitz, are much admired.
Dessau was probably founded by Albert the Bear; it had attained civic rights as early as 1213. It first began to grow into importance at the close of the 17th century, in consequence of the religious emancipation of the Jews in 1686, and of the Lutherans in 1697.
See Würdig, _Chronik der Stadt Dessau_ (Dessau, 1876).
DESSEWFFY, AUREL, COUNT (1808-1842), Hungarian journalist and politician, eldest son of Count József Dessewffy and Eleonora Sztaray, was born at Nagy-Mihály, county Zemplén, Hungary. Carefully educated at his father's house, he was accustomed to the best society of his day. While still a child he could declaim most of the _Iliad_ in Greek without a book, and read and quoted Tacitus with enthusiasm. Under the noble influence of Ferencz Kazinczy he became acquainted with the chief masterpieces of European literature in their original tongues. He was
## particularly fond of the English, and one of his early idols was Jeremy
Bentham. He regularly accompanied his father to the diets of which he was a member, followed the course of the debates, of which he kept a journal, and made the acquaintance of the great Széchenyi, who encouraged his aspirations. On leaving college, he entered the royal aulic chancellery, and in 1832 was appointed secretary of the royal stadtholder at Buda. The same year he turned his attention to politics and was regarded as one of the most promising young orators of the day, especially during the sessions of the diet of 1832-1836, when he had the courage to oppose Kossuth. At the Pressburg diet in 1840 Dessewffy was already the leading orator of the more enlightened and progressive Conservatives, but incurred great unpopularity for not going far enough, with the result that he was twice defeated at the polls. But his reputation in court circles was increasing; he was appointed a member of the committee for the reform of the criminal law in 1840; and, the same year with a letter of recommendation from Metternich in his pocket, visited England and France, Holland and Belgium, made the acquaintance of Thiers and Heine in Paris, and returned home with an immense and precious store of practical information. He at once proceeded to put fresh life into the despondent and irresolute Conservative party, and the Magyar aristocracy, by gallantly combating in the _Világ_ the opinions of Kossuth's paper, the _Pesti Hírlap_. But the multiplicity of his labours was too much for his feeble physique, and he died on the 9th of February 1842, at the very time when his talents seemed most indispensable.
See _Aus den Papieren des Grafen Aurel Dessewffy_ (Pest, 1843); _Memorial Wreath to Count Aurel Dessewffy_ (Hung.), (Budapest, 1857); _Collected Works of Count Dessewffy, with a Biography_ (Hung.), (Budapest, 1887). (R. N. B.)
DESSOIR, LUDWIG (1810-1874), German actor, whose name was originally Leopold Dessauer, was born on the 15th of December 1810 at Posen, the son of a Jewish tradesman. He made his first appearance on the stage there in 1824 in a small part. After some experience at the theatre in Posen and on tour, he was engaged at Leipzig from 1834 to 1836. Then he was attached to the municipal theatre of Breslau, and in 1837 appeared at Prague, Brünn, Vienna and Budapest, where he accepted an engagement which lasted until 1839. He succeeded Karl Devrient at Karlsruhe, and went in 1847 to Berlin, where he acted Othello and Hamlet with such extraordinary success that he received a permanent engagement at the Hof-theater. From 1849 to 1872, when he retired on a pension, he played 110 parts, frequently on tour, and in 1853 acting in London. He died on the 30th of December 1874 in Berlin. Dessoir was twice married; his first wife, Theresa, a popular actress (1810-1866), was separated from him a year after marriage; his second wife went mad on the death of her child. By his first wife Dessoir had one son, the actor Ferdinand Dessoir (1836-1892). In spite of certain physical disabilities Ludwig Dessoir's genius raised him to the first rank of actors, especially as interpreter of Shakespeare's characters. G. H. Lewes placed Dessoir's Othello above that of Kean, and the _Athenaeum_ preferred him in this part to Brooks or Macready.
DESTOUCHES, PHILIPPE (1680-1754), French dramatist, whose real name was Néricault, was born at Tours in April 1680. When he was nineteen years of age he became secretary to M. de Puysieux, the French ambassador in Switzerland. In 1716 he was attached to the French embassy in London, where he remained for six years under the abbé Dubois. He contracted with a Lancashire lady, Dorothea Johnston, a marriage which was not avowed for some years. He drew a picture later of his own domestic circumstances in _Le Philosophe marié_ (1726). On his return to France (1723) he was elected to the Academy, and in 1727 he acquired considerable estates, the possession of which conferred the privileges of nobility. He spent his later years at his château of Fortoiseau near Melun, dying on the 4th of July 1754. His early comedies were: _Le Curieux Impertinent_ (1710), _L'Ingrat_ (1712), _L'Irrésolu_ (1713) and _Le Médisant_ (1715). The best of these is _L'Irrêsolu_, in which Dorante, after hesitating throughout the play between Julie and Célimène, marries Julie, but concludes the play with the reflection:--
"J'aurais mieux fait, je crois, d'épouser Célimène."
After eleven years of diplomatic service Destouches returned to the stage with the _Philosophe marié_ (1727), followed in 1732 by his masterpiece _Le Glorieux_, a picture of the struggle then beginning between the old nobility and the wealthy _parvenus_ who found their opportunity in the poverty of France. Destouches wished to revive the comedy of character as understood by Molière, but he thought it desirable that the moral should be directly expressed. This moralizing tendency spoilt his later comedies. Among them may be mentioned: _Le Tambour nocturne_ (1736), _La Force du naturel_ (1750) and _Le Dissipateur_ (1736).
His works were issued in collected form in 1755, 1757, 1811 and, in a limited edition (6 vols.), 1822.
DESTRUCTORS. The name destructors is applied by English municipal engineers to furnaces, or combinations of furnaces, commonly called "garbage furnaces" in the United States, constructed for the purpose of disposing by burning of town refuse, which is a heterogeneous mass of material, including, besides general household and ash-bin refuse, small quantities of garden refuse, trade refuse, market refuse and often street sweepings. The mere disposal of this material is not, however, by any means the only consideration in dealing with it upon the destructor system. For many years past scientific experts, municipal engineers and public authorities have been directing careful attention to the utilization of refuse as fuel for steam production, and such progress in this direction has been made that in many towns its calorific value is now being utilized daily for motive-power purposes. On the other hand, that proper degree of caution which is obtained only by actual experience must be exercised in the application of refuse fuel to steam-raising. When its value as a low-class fuel was first recognized, the idea was disseminated that the refuse of a given population was of itself sufficient to develop the necessary steam-power for supplying that population with the electric light. The economical importance of a combined destructor and electric undertaking of this character naturally presented a somewhat fascinating stimulus to public authorities, and possibly had much to do with the development both of the adoption of the principle of dealing with refuse by fire, and of lighting towns by electricity. However true this phase of the question may be as the statement of a theoretical scientific fact, experience so far does not show it to be a basis upon which engineers may venture to calculate, although, as will be seen later, under certain circumstances of equalized load, which must be considered upon their merits in each case, a well-designed destructor plant can be made to perform valuable commercial service to an electric or other power-using undertaking. Further, when a system, thermal or otherwise, for the storage of energy can be introduced and applied in a trustworthy and economical manner, the degree of advantage to be derived from the utilization of the waste heat from destructors will be materially enhanced.
Composition and quantity of refuse.
The composition of house refuse, which must obviously affect its calorific value, varies considerably in different localities, according to the condition, habits and pursuits of the people. Towns situated in coal-producing districts invariably yield a refuse richer in unconsumed carbon than those remote therefrom. It is also often found that the refuse from different parts of the same town varies considerably--that from the poorest quarters frequently proving of greater calorific value than that from those parts occupied by the rich and middle classes. This has been attributed to the more extravagant habits of the working classes in neglecting to sift the ashes from their fires before disposing of them in the ash-bin. In Bermondsey, for example, the refuse has been found to possess an unusually high calorific value, and this experience is confirmed in other parts of the metropolis. Average refuse consists of breeze (cinder and ashes), coal and coke, fine dust, vegetable and animal matters, straw, shavings, cardboard, bottles, tins, iron, bones, broken crockery and other matters in very variable proportions according to the character of the district from which it is collected. In London the quantity of house refuse amounts approximately to 1¼ million tons per annum, which is equivalent to from 4 cwt. to 5 cwt. per head per annum, or to from 200 to 250 tons per 1000 of the population per annum. Statistics, however, vary widely in different districts. In the vicinity of the metropolis the amount varies from 2.5 cwt. per head per annum at Leyton to 3.5 cwt. at Hornsey, and to as much as 7 cwt. at Ealing. In the north of England the total house refuse collected, exclusive of street sweepings, amounts on the average to 8 cwt. per head per annum. Speaking generally, throughout the country an amount of from 5 cwt. to 10 cwt. per head per annum should be allowed for. A cubic yard of ordinary house refuse weighs from 12¼ to 15 cwt. Shop refuse is lighter, frequently containing a large proportion of paper, straw and other light wastes. It sometimes weighs as little as 7¼ cwt. per cubic yard. A load, by which refuse is often estimated, varies in weight from 15 cwt. to 1½ tons.
Refuse disposal.
The question how a town's refuse shall be disposed of must be considered both from a commercial and a sanitary point of view. Various methods have been practised. Sometimes the household ashes, &c., are mixed with pail excreta, or with sludge from a sewage farm, or with lime, and disposed of for agricultural purposes, and sometimes they are conveyed in carts or by canal to outlying and country districts, where they are shot on waste ground or used to fill up hollows and raise the level of marshland. Such plans are economical when suitable outlets are available. To take the refuse out to sea in hopper barges and sink it in deep water is usually expensive and frequently unsatisfactory. At Bermondsey, for instance, the cost of barging is about 2s. 9d. a ton, while the material may be destroyed by fire at a cost of from 10d. to 1s. a ton, exclusive of interest and sinking fund on the cost of the works. In other cases, as at Chelsea and various dust contractors' yards, the refuse is sorted and its ingredients are sold; the fine dust may be utilized in connexion with manure manufactories, the pots and pans employed in forming the foundations of roads, and the cinders and vegetable refuse burnt to generate steam. In the Arnold system, carried out in Philadelphia and other American towns, the refuse is sterilized by steam under pressure, the grease and fertilizing substances being extracted at the same time; while in other systems, such as those of Weil and Porno, and of Defosse, distillation in closed vessels is practised. But the destructor system, in which the refuse is burned to an innocuous clinker in specially constructed furnaces, is that which must finally be resorted to, especially in districts which have become well built up and thickly populated.
Types of destructors.
Various types of furnaces and apparatus have from time to time been designed, and the subject has been one of much experiment and many failures. The principal towns in England which took the lead in the adoption of the refuse destructor system were Manchester, Birmingham, Leeds, Heckmondwike, Warrington, Blackburn, Bradford, Bury, Bolton, Hull, Nottingham, Salford, Ealing and London. Ordinary furnaces, built mostly by dust contractors, began to come into use in London and in the north of England in the second half of the 19th century, but they were not scientifically adapted to the purpose, and necessitated the admixture of coal or other fuel with the refuse to ensure its cremation. The Manchester corporation erected a furnace of this description about the year 1873, and Messrs Mead & Co. made an unsatisfactory attempt in 1870 to burn house refuse in closed furnaces at Paddington. In 1876 Alfred Fryer erected his destructor at Manchester, and several other towns adopted this furnace shortly afterwards. Other furnaces were from time to time brought before the public, among which may be mentioned those of Pearce and Lupton, Pickard, Healey, Thwaite, Young, Wilkinson, Burton, Hardie, Jacobs and Odgen. In addition to these the "Beehive" and the "Nelson" destructors became well known. The former was introduced by Stafford and Pearson of Burnley, and one was erected in 1884 in the parish yard at Richmond, Surrey, but the results being unsatisfactory, it was closed during the following year. The "Nelson" furnace, patented in 1885 by Messrs Richmond and Birtwistle, was erected at Nelson-in-Marsden, Lancashire, but being very costly in working was abandoned. The principal types of destructors now in use are those of Fryer, Whiley, Horsfall, Warner, Meldrum, Beaman and Deas, Heenan and Froude, and the "Sterling" destructor erected by Messrs Hughes and Stirling.
[Illustration: FIG. 1.--Fryer's Destructor.]
Fryer's.
The general arrangement of the destructor patented[1] by Alfred Fryer in 1876 is illustrated in fig. 1. An installation upon this principle consists of a number of furnaces or cells, usually arranged in pairs back to back, and enclosed in a rectangular block of brickwork having a flat top, upon which the house refuse is tipped from the carts.
[Illustration: FIG. 2.--Horsfall's Improved Destructor.]
A large main flue, which also forms the dust chamber, is placed underneath the furnace hearths. The Fryer furnace ordinarily burns from 4 to 6 tons of refuse per cell per 24 hours. It will be observed that the outlets for the products of combustion are placed at the back near the refuse feed opening, an arrangement which is imperfect in design, inasmuch as while a charge of refuse is burning upon the furnace bars the charge which is to follow lies on the dead hearth near the outlet flue. Here it undergoes drying and partial decomposition, giving off offensive empyreumatic vapours which pass into the flue without being exposed to sufficient heat to render them entirely inoffensive. The serious nuisances thus produced in some instances led to the introduction of a second furnace, or "cremator," patented by C. Jones of Ealing in 1885, which was placed in the main flue leading to the chimney-shaft, for the purpose of resolving the organic matters present in the vapour, but the greatly increased cost of burning due to this device led to its abandonment in many cases. This type of cell was largely used during the early period of the history of destructors, but has to a considerable extent given place to furnaces of more modern design.
[Illustration: FIG. 3. - Meldrum's Destructor at Darwen]
Whiley's.
A furnace[2] patented in 1891 by Mr Henry Whiley, superintendent of the scavenging department of the Manchester corporation, is automatic in its action and was designed primarily with a view to saving labour--the cells being fed, stoked and clinkered automatically. There is no drying hearth, and the refuse carts tip direct into a shoot or hopper at the back which conducts the material directly on to movable eccentric grate bars. These automatically traverse the material forward into the furnace, and finally push it against a flap-door which opens and allows it to fall out. This apparatus is adapted for dealing with screened rather than unscreened refuse, since it suffers from the objection that the motion of the bars tends to allow fine particles to drop through unburnt. Some difficulty has been experienced from the refuse sticking in the hopper, and exception may also be taken to the continual flapping of the door when the clinker passes out, as cold air is thereby admitted into the furnace. As in the Fryer cell, the outlet for the products of combustion into the main flue is close to the point where the crude refuse is fed into the furnace, and the escape of unburnt vapours is thus facilitated. Forced draught is applied by means of a Roots blower. The Manchester corporation has 28 cells of this type in use, and the approximate amount of refuse burnt per cell per 24 hours is from 6 to 8 tons at a cost per ton for labour of 3.47 pence.
Horsfall's.
Horsfall's destructor[3] (fig. 2) is a high-temperature furnace of modern type which has been adopted largely in Great Britain and on the continent of Europe. In it some of the general features of the Fryer cell are retained, but the details differ considerably from those of the furnaces already described. Important points in the design are the arrangement of the flues and flue outlets for the products of combustion, and the introduction of a blast duct through which air is forced into a closed ash-pit. The feeding-hole is situated at the back of and above the furnace, while the flue opening for the emission of the gaseous products is placed at the front of the furnace over the dead plate; thus the gases distilled from the raw refuse are caused to pass on their way to the main flue over the hottest part of the furnace and through the flue opening in the red-hot reverberatory arch. The steam jet, which plays an important
## part in the Horsfall furnace, forces air into the closed ash-pit at a
pressure of about ¾ to 1 in. of water, and in this way a temperature varying from 1500° to 2000° F., as tested by a thermo-electric pyrometer, is maintained in the main flue. In a battery of cells the gases from each are delivered into one main flue, so that a uniform temperature is maintained therein sufficiently high to prevent noxious vapours from reaching the chimney. The cells being charged and clinkered in rotation, when the fire in one is green, in the others it is at its hottest, and the products of combustion do not reach the boiler surfaces until after they have been mixed in the main flue. The cast iron boxes which are provided at the sides of the furnaces, and through which the blast air is conveyed on its way to the grate, prevent the adhesion of clinker to the side walls of the cells, and very materially preserve the brickwork, which otherwise becomes damaged by the tools used to remove the clinker. The wide clinkering doors are suspended by counterbalance weights and open vertically. The rate of working of these cells varies from 8 tons per cell per 24 hours at Oldham to 10 tons per cell at Bradford, where the furnaces are of a later type. The cost of labour in stoking and clinkering is about 6d. per ton of the refuse treated at Bradford, and 9d. per ton at Oldham, where the rate of wages is higher. Well-constructed and properly-worked plants of this type should give rise to no nuisance, and may be located in populous neighbourhoods without danger to the public health or comfort. Installations were put down at Fulham (1901), Hammerton Street, Bradford (1900), West Hartlepool (1904), and other places, and the surplus power generated is employed in the production of electric energy.
Warner's.
Warner's destructor,[4] known as the "Perfectus," is, in general arrangement, similar to Fryer's, but differs in being provided with special charging hoppers, dampers in flues, dust-catching arrangements, rocking grate bars and other improvements. The refuse is tipped into feeding-hoppers, consisting of rectangular cast iron boxes over which plates are placed to prevent the escape of smoke and fumes. At the lower portion of the feeding-hopper is a flap-door working on an axis and controlled by an iron lever from the tipping platform. When refuse is to be fed into the furnace the lever is thrown over, the contents of the hopper drop on to the sloping firebrick hearth beneath, and the door is at once closed again. The door should be kept open as short a time as possible in order to prevent the admission of cold air into the furnace at the back end, since this leads to the lowering of the temperature of the cells and main flue, and also to paper and other light refuse being carried into the flues and chimney. The flues of each furnace are provided with dampers, which are closed during the process of clinkering in order to keep up the heat. The cells are each 5 ft. wide and 11 ft. deep, the rearmost portion consisting of a firebrick drying hearth, and the front of rocking grate bars upon which the combustion takes place. The crown of each cell is formed of a reverberatory firebrick arch having openings for the emission of the products of combustion. The flap dampers which are fitted to these openings are operated by horizontal spindles passing through the brickwork to the front of the cell, where they are provided with levers or handles; thus each cell can be worked independently of the others. With the view of increasing the steam-raising capabilities of the furnace, forced draught is sometimes applied and a tubular boiler is placed close to the cells. The amount of refuse consumed varies from 5 tons to 8 tons per cell per 24 hours. At Hornsey, where 12 cells of this type are in use, the cost of labour for burning the refuse is 9½d. per ton.
Meldrum's
The Meldurm "Simplex" destructor (fig. 3), a type of furnace which yields good steam-raising results, is in successful operation at Rochdale, Hereford, Darwen, Nelson, Plumstead and Woolwich, at each of which towns the production of steam is an important consideration. Cells have also been laid down at Burton, Hunstanton, Blackburn and Shipley, and more recently at Burnley, Cleckheaton, Lancaster, Nelson, Sheerness and Weymouth. In general arrangement the destructor differs considerably from those previously described. The grates are placed side by side without separation except by dead plates, but, in order to localize the forced draught, the ash-pit is divided into parts corresponding with the different grate areas. Each ash-pit is closed air-tight by a cast iron plate, and is provided with an air-tight door for removing the fine ash. Two patent Meldrum steam-jet blowers are provided for each furnace, supplying any required pressure of blast up to 6 in. water column, though that usually employed does not exceed 1½ in. The furnaces are designed for hand-feeding from the front, but hopper-feeding can be applied if desirable. The products of combustion either pass away from the back of each fire-grate into a common flue leading to boilers and the chimney-shaft, or are conveyed sideways over the various grates and a common fire-bridge to the boilers or chimney. The heat in the gases, after passing the boilers, is still further utilized to heat the air supplied to the furnaces, the gases being passed through an air heater or continuous regenerator consisting of a number of cast iron pipes from which the air is delivered through the Meldrum "blowers" at a temperature of about 300° F. That a high percentage (15 to 18%) of CO_2 is obtained in the furnaces proves a small excess of free oxygen, and no doubt explains the high fuel efficiency obtained by this type of destructor. High-pressure boilers of ample capacity are provided for the accumulation during periods of light load of a reserve of steam, the storage being obtained by utilizing the difference between the highest and lowest water-levels and the difference between the maximum and working steam-pressure. Patent locking fire-bars, to prevent lifting when clinkering, are used in the furnace and have a good life. At Rochdale the Meldrum furnaces consume from 53 lb. to 66 lb. of refuse per square foot of grate area per hour, as compared with 22.4 lb. per square foot in a low-temperature destructor burning 6 tons per cell per 24 hours with a grate area of 25 sq. ft. The evaporative efficiency of the Rochdale furnaces varies from 1.39 lb. to 1.87 lb. of water (actual) per 1 lb. of refuse burned, and an average steam-pressure of about 114 lb. per square inch is maintained. The cost of labour and supervision amounts to 10d. per ton of refuse dealt with. A Lancashire boiler (22 ft. by 6 ft. 6 in.) at the Sewage Outfall Works, Hereford, evaporates with refuse fuel 2980 lb. of water per hour, equal to 149 indicated horse-power. About 54 lb. of refuse are burnt per square foot of grate area per hour with an evaporation of 1.82 lb. of water per pound of refuse.
[Illustration: FIG. 4.--Beaman and Deas Destructor at Leyton.]
Beaman and Deas.
The Beaman and Deas destructor[5] (fig. 4) has attracted much attention from public authorities, and successful installations are in operation at Warrington, Dewsbury, Leyton, Canterbury, Llandudno, Colne, Streatham, Rotherhithe, Wimbledon, Bolton and elsewhere. Its essential features include a level-fire grate with ordinary type bars, a high-temperature combustion chamber at the back of the cells, a closed ash-pit with forced draught, provision for the admission of a secondary air-supply at the fire-bridge, and a firebrick hearth sloping at an angle of about 52°. From the refuse storage platform the material is fed into a hopper mouth about 18 in. square, and slides down the firebrick hearth, supported by T-irons, to the grate bars, over which it is raked and spread with the assistance of long rods manipulated through clinkering doors placed at the sides of the cells. A secondary door in the rear of the cell facilitates the operation. The fire-bars, spaced only 3/32 in. apart, are of the ordinary stationary type. Vertically, under the fire-bridge, is an air-conduit, from the top of which lead air blast pipes 12 in. in diameter discharging into a hermetically closed ash-pit under the grate area. The air is supplied from fans (Schiele's patent) at a pressure of from 1½ to 2 in. of water, and is controlled by means of baffle valves worked by handles on either side of the furnace, conveniently placed for the attendant. The forced draught tends to keep the bars cool and lessen wear and tear. The fumes from the charge drying on the hearth pass through the fire and over the red-hot fire-bridge, which is perforated longitudinally with air-passages connected with a small flue leading from a grated opening on the face of the brickwork outside; in this way an auxiliary supply of heated oxygen is fed into the combustion chamber. This chamber, in which a temperature approaching 2000° F. is attained, is fitted with large iron doors, sliding with balance weights, which allow the introduction of infected articles, bad meat, &c., and also give access for the periodical removal of fine ash from the flues. The high temperatures attained are utilized by installing one boiler, preferably of the Babcock & Wilcox water-tube type, for each pair of cells, so that the gases, on their way from the combustion chamber to the main flue, pass three times between the boiler tubes. A secondary furnace is provided under the boiler for raising steam by coal, if required, when the cells are out of use. The grate area of each cell is 25 sq. ft., and the consumption varies from 16 up to 20 tons of refuse per cell per 24 hours. In a 24-hours' test made by the superintendent of the cleansing department, Leeds, at the Warrington installation, the quantity of water evaporated per pound of refuse was 1.14 lb., the average temperature in the combustion chamber 2000° F. by copper-wire test, and the average air pressure with forced draught 2½ in. (water-gauge). At Leyton, which has a population of over 100,000, an 8-cell plant of this type is successfully dealing with house refuse and filter press cakes of sewage sludge from the sewage disposal works adjoining, and even with material of this low calorific value the total steam-power produced is considerable. Each cell burns about 16 tons of the mixture in 24 hours and develops about 35 indicated horse-power continuously, at an average steam-pressure in the boilers of 105 lb. The cost of labour at Leyton for burning the mixed refuse is about 1s. 7d. per ton; at Llandudno, where four cells were laid down in connexion with the electric-light station in 1898, it is 1s. 3¼d., and at Warrington 9½d. per ton of refuse consumed. Combustion is complete, and the destructor may be installed in populous districts without nuisance to the inhabitants. Further patents (Wilkie's improvements) have been obtained by Meldrum Brothers (Manchester) in connexion with this destructor.
Heenan.
The Heenan furnaces are in operation at Farnworth, Gloucester, Barrow-in-Furness, Northampton, Mansfield, Wakefield, Blackburn, Levenshulme, Kings Norton, Worthing, Birmingham and other places, and are now dealing with over 1200 tons of refuse per day. The general arrangement of this destructor somewhat resembles that of the Meldrum type. The cells intercommunicate, and the mechanical mixture of the gases arising from the furnace grates of the various cells is sought by the introduction of a special design of reverberatory arch overlying the grates. The standard arrangement of this destructor embodies all modern arrangements for high-temperature refuse destruction and steam-power generation.
Sterling.
Destructors of the "Sterling" type, combined with electric-power generating stations, are installed at Hackney (1901), Bermondsey (1902) and Frederiksberg (1903)--the first-named plant being probably the most powerful combined destructor and electricity station yet erected. In these modern stations the recognized requirements of an up-to-date refuse-destruction plant have been well considered and good calorific results are also obtained.
In addition to the above-described destructors, other forms have been introduced from time to time, but adopted to a less degree; amongst these may be mentioned Baker's destructor, Willshear's, Hanson's Utilizer, Mason's Gasifier, the Bennett-Phythian, Cracknell's (Melbourne, Victoria), Coltman's (Loughborough), Willoughby's, and Healey's improved destructors. On the continent of Europe systems for the treatment of refuse have also been devised. Among these may be mentioned those of M. Defosse and M. Helouis. The former has endeavoured to burn the refuse in large quantities by using a forced draught and only washing the smoke.[6] Helouis has extended the operation by using the heat from the combustion of the refuse for drying and distilling the material which is brought gradually on to the grate.
Destructor accessories.
Boulnois and Brodie's improved charging tank is a labour-saving apparatus consisting of a wrought iron truck, 5 ft. wide by 3 ft. deep, and of sufficient length to hold not less than 12 hours supply for the two cells which it serves. The truck, which moves along a pair of rails across the top of the destructor, may be worked by one man. It is divided into compartments holding a charge of refuse in each, and is provided with a pair of doors in the bottom, opening downwards, which are supported by a series of small wheels running on a central rail. A special feeding opening in the reverberatory arch of the cell of the width of the truck, situated over the drying hearth, is formed by a firebrick arch fitted into a frame capable of being moved backwards and forwards by means of a lever. The charging truck, when empty, is brought under the tipping platform, and the carts tip directly into it. When one of the cells has to be fed, the truck is moved along, so that one of the divisions is immediately over the feeding opening, and the wheel holding up the bottom doors rests upon the central rail, which is continued over the movable covering arch. Then the movable arch is rolled back, the doors are released, and the contents are discharged into the cell, so that no handling of the refuse is required from tipping to feeding. This apparatus is in operation at Liverpool, Shoreditch, Cambridge and elsewhere.
Various forms of patent movable fire-bars have been employed in destructor furnaces. Among these may be mentioned Settle's,[7] Vicar's,[8] Riddle's rocking bars,[9] Horsfall's self-feeding apparatus,[10] and Healey's movable bars;[11] but complicated movable arrangements are not to be recommended, and experience greatly favours the use of a simple stationary type of fire-bar.
[Illustration: FIG. 5.--Leyton Destructor. Block Plan, showing general arrangement of the Works.]
A dust-catching apparatus has been designed and erected at Edinburgh, by the Horsfall Furnace Syndicate, in order to overcome difficulties in regard to the escape of flue dust, &c., from the destructor chimney. Externally, it appears a large circular block of brickwork, 18 ft. in diameter and 13 ft. 7 in. high, connected with the main flue, and situated between the destructor cells and the boiler. Internally it consists of a spiral flue traversing the entire circumference and winding upwards to the top of the chamber. There is an interior well or chamber 6 ft. diameter by 12 ft. high, having a domed top, and communicating with the outer spiral flue by four ports at the top of the chamber. Dust traps, baffle walls and cleaning doors are also provided for the retention and subsequent weekly removal of the flue dust. The apparatus forms a large reservoir of heat maintained at a steady temperature of from 1500º to 1800° F., and is useful in keeping up steam in the boiler at an equable pressure for a long period. It requires no attention, and has proved successful for its purpose.
Travelling cranes for transporting refuse and feeding cells are sometimes employed at destructor stations, as, for example, at Hamburg. Here the transportation of the refuse is effected by means of specially constructed water-tight iron wagons, containing detachable boxes provided with two double-flap doors at the top for loading, and one flap-door at the back for unloading. There are thirty-six furnaces of the Horsfall type placed in two ranks, each arranged in three blocks of six in the large furnace hall. An electric crane running above each rank lifts the boxes off the wagons and carries them to the feeding-hole of each well. Here the box is tipped up by an electric pulley and emptied on to the furnace platform. When the travelling crane is used, the carts (four-wheeled) bringing the refuse may be constructed so that the body of the carriage can be taken off the wheels, lifted up and tipped direct over the furnace as required, and returned again to its frame. The adoption of the travelling crane admits of the reduction in size of the main building, as less platform space for unloading refuse carts is required; the inclined roadway may also be dispensed with. Where a destructor site will not admit of an inclined roadway and platform, the refuse may be discharged from the collecting carts into a lift; and thence elevated into the feeding-bins.
Other accessory plant in use at most modern destructor stations includes machinery for the removal, crushing and various means of utilization of the residual clinker, stoking tools, air heaters or regenerators for the production of hot-air blast to the furnaces, superheaters and thermal storage arrangements for equalizing the output of power from the station during the 24-hours' day.
Working of destructors.
The general arrangement of a battery of refuse cells at a destructor station is illustrated by fig. 5. The cells are arranged either side by side, with a common main flue in the rear, or back to back with the main flue placed in the centre and leading to a tall chimney-shaft. The heated gases on leaving the cells pass through the combustion chamber into the main flue, and thence go forward to the boilers, where their heat is absorbed and utilized. Forced draught, or in many cases, hot blast, is supplied from fans through a conduit commanding the whole of the cells. An inclined roadway, of as easy gradient as circumstances will admit, is provided for the conveyance of the refuse to the tipping platform, from which it is fed through feed-holes into the furnaces. In the installation of a destructor, the choice of suitable plant and the general design of the works must be largely dependent upon local requirements, and should be entrusted to an engineer experienced in these matters. The following primary considerations, however, may be enumerated as materially affecting the design of such works:--
(a) The plant must be simple, easily worked without stoppages, and without mechanical complications upon which stokers may lay the blame for bad results. (b) It must be strong, must withstand variations of temperature, must not be liable to get out of order, and should admit of being readily repaired. (c) It must be such as can be easily understood by stokers or firemen of average intelligence, so that the continuous working of the plant may not be disorganized by change of workmen. (d) A sufficiently high temperature must be attained in the cells to reduce the refuse to an entirely innocuous clinker, and all fumes or gases should pass either through an adjoining red-hot cell or through a chamber whose temperature is maintained by the ordinary working of the destructor itself at a degree sufficient to exclude the possibility of the escape of any unconsumed gases, vapours or
## particles. The temperature may vary between 1500° and 2000°. (e) The
plant must be so worked that while some of the cells are being recharged, others are at a glowing red heat, in order that a high temperature may be uniformly maintained. (f) The design of the furnaces must admit of clinkering and recharging being easily and quickly performed, the furnace doors being open for a minimum of time so as to obviate the inrush of cold air to lower the temperature ...
(_Continued in volume 8, slice 3, page 109._)
FOOTNOTES:
[1] Patent No. 3125 (1876).
[2] Patent No. 8271 (1891).
[3] Patents No. 8999 (1887); No. 14,709 (1888); No. 22,531 (1891).
[4] Patent No. 18,719 (1888).
[5] Patents No. 15,598 (1893) and 23,712 (1893); also Beaman and Deas Sludge Furnace, Patent No. 13,029 (1894).
[6] _Compte Rendu des Travaux de la Société des Ingénieurs Civils de France_, folio 775 (June 1897).
[7] Patent No. 15,482 (1885).
[8] Patents No. 1955 (1867) and No. 378 (1879).
[9] Patent No. 4896 (1891).
[10] Patent No. 20,207 (1892).
[11] Patents No. 18,398 (1892) and No. 12,990 (1892).