PART III

.

The tests were made at the laboratories of the U.S. Forest Service, in cooperation with the following institutions: Yale Forest School, Purdue University, University of California, University of Oregon, University of Washington, University of Colorado, and University of Wisconsin.

Tables XVIII and XIX give the average results obtained from tests on green material, while Tables XX and XXI give average results from tests on air-seasoned material. The small specimens, which were invariably 2" X 2" in cross section, were free from defects such as knots, checks, and cross grain; all other specimens were representative of material secured in the open market. The relation of stresses developed in different structural forms to those developed in the small clear specimens is shown for each factor in the column headed "Ratio to 2" X 2"." Tests to determine the mechanical properties of different species are often confined to small, clear specimens. The ratios included in the tables may be applied to such results in order to approximate the strength of the species in structural sizes, and containing the defects usually encountered, when tests on such forms are not available.

A comparison of the results of tests on seasoned material with those from tests on green material shows that, without exception, the strength of the 2" X 2" specimens is increased by lowering the moisture content, but that increase in strength of other sizes is much more erratic. Some specimens, in fact, show an apparent loss in strength due to seasoning. If structural timbers are seasoned slowly, in order to avoid excessive checking, there should be an increase in their strength. In the light of these facts it is not safe to base working stresses on results secured from any but green material. For a discussion of factors of safety and safe working stresses for structural timbers see the Manual of the American Railway Engineering Association, Chicago, 1911. A table from that publication, giving working unit stresses for structural timber, is reproduced in this book, see Table XXII.

|-----------------------------------------------------------------------------------------------------------------------------------| | TABLE XVIII TABLE XVIII | |-----------------------------------------------------------------------------------------------------------------------------------| | BENDING TESTS ON GREEN MATERIAL | |-----------------------------------------------------------------------------------------------------------------------------------| | | Sizes | | | | F.S. at E.L. | M. of R. | M. of E. | Calculated | | |-----------------| Num- | Per | Rings | | | | shear | | Species | | | ber | cent | per |-----------------+-----------------+-----------------+-----------------| | | Cross | Span | of | mois- | inch | Average | Ratio | Average | Ratio | Average | Ratio | Average | Ratio | | | Section | | tests | ture | | per sq. | to 2" | per sq. | to 2" | per sq. | to 2" | per sq. | to 2" | | | | | | | | inch | by 2" | inch | by 2" | inch | by 2" | inch | by 2" | |-----------------+----------+------+-------+-------+-------+---------+-------+---------+-------+---------+-------+---------+-------| | | | | | | | | | | | 1,000 | | | | | | Inches | Ins. | | | | Lbs. | | Lbs. | | lbs. | | Lbs. | | | | | | | | | | | | | | | | | | Longleaf pine | 12 by 12 | 138 | 4 | 28.6 | 9.7 | 4,029 | 0.83 | 6,710 | 0.74 | 1,523 | 0.99 | 261 | 0.86 | | | 10 by 16 | 168 | 4 | 26.8 | 16.7 | 6,453 | .85 | 6,453 | .71 | 1,626 | 1.05 | 306 | 1.01 | | | 8 by 16 | 156 | 7 | 28.4 | 14.6 | 3,147 | .64 | 5,439 | .60 | 1,368 | .89 | 390 | 1.29 | | | 6 by 16 | 132 | 1 | 40.3 | 21.8 | 4,120 | .83 | 6,460 | .71 | 1,190 | .77 | 378 | 1.25 | | | 6 by 10 | 180 | 1 | 31.0 | 6.2 | 3,580 | .72 | 6,500 | .72 | 1,412 | .92 | 175 | .58 | | | 6 by 8 | 180 | 2 | 27.0 | 8.2 | 3,735 | .75 | 5,745 | .63 | 1,282 | .83 | 121 | .40 | | | 2 by 2 | 30 | 15 | 33.9 | 14.1 | 4,950 | 1.00 | 9,070 | 1.00 | 1,540 | 1:00 | 303 | 1.00 | | Douglas fir | 8 by 16 | 180 | 191 | 31.5 | 11.0 | 3,968 | .76 | 5,983 | .72 | 1,517 | .95 | 269 | .81 | | | 5 by 8 | 180 | 84 | 30.1 | 10.8 | 3,693 | .71 | 5,178 | .63 | 1,533 | .96 | 172 | .52 | | | 2 by 12 | 180 | 27 | 35.7 | 20.3 | 3,721 | .71 | 5,276 | .64 | 1,642 | 1.03 | 256 | .77 | | | 2 by 10 | 180 | 26 | 32.9 | 21.6 | 3,160 | .60 | 4,699 | .57 | 1,593 | 1.00 | 189 | .57 | | | 2 by 8 | 180 | 29 | 33.6 | 17.6 | 3,593 | .69 | 5,352 | .65 | 1,607 | 1.01 | 171 | .51 | | | 2 by 2 | 24 | 568 | 30.4 | 11.6 | 5,227 | 1.00 | 9,070 | 1.00 | 1,540 | 1.00 | 303 | 1.00 | | Douglas fir | | | | | | | | | | | | | | | (fire-killed) | 8 by 16 | 180 | 30 | 36.8 | 10.9 | 3,503 | .80 | 4,994 | .64 | 1,531 | .94 | 330 | 1.19 | | | 2 by 12 | 180 | 32 | 34.2 | 17.7 | 3,489 | .80 | 5,085 | .66 | 1,624 | .99 | 247 | .89 | | | 2 by 10 | 180 | 32 | 38.9 | 18.1 | 3,851 | .88 | 5,359 | .69 | 1,716 | 1.05 | 216 | .78 | | | 2 by 8 | 180 | 31 | 37.0 | 15.7 | 3,403 | .78 | 5,305 | .68 | 1,676 | 1.02 | 169 | .61 | | | 2 by 2 | 30 | 290 | 33.2 | 17.2 | 4,360 | 1.00 | 7,752 | 1.00 | 1,636 | 1.00 | 277 | 1.00 | | Shortleaf pine | 8 by 16 | 180 | 12 | 39.5 | 12.1 | 3,185 | .73 | 5,407 | .70 | 1,438 | 1.03 | 362 | 1.40 | | | 8 by 14 | 180 | 12 | 45.8 | 12.7 | 3,234 | .74 | 5,781 | .75 | 1,494 | 1.07 | 338 | 1.31 | | | 8 by 12 | 180 | 24 | 52.2 | 11.8 | 3,265 | .75 | 5,503 | .71 | 1,480 | 1.06 | 277 | 1.07 | | | 5 by 8 | 180 | 24 | 47.8 | 11.5 | 3,519 | .81 | 5,732 | .74 | 1,485 | 1.06 | 185 | .72 | | | 2 by 2 | 30 | 254 | 51.7 | 13.6 | 4,350 | 1.00 | 7,710 | 1.00 | 1,395 | 1.00 | 258 | 1.00 | | Western larch | 8 by 16 | 180 | 32 | 51.0 | 25.3 | 3,276 | .77 | 4,632 | .64 | 1,272 | .97 | 298 | 1.11 | | | 8 by 12 | 180 | 30 | 50.3 | 23.2 | 3,376 | .79 | 5,286 | .73 | 1,331 | 1.02 | 254 | .94 | | | 5 by 8 | 180 | 14 | 56.0 | 25.6 | 3,528 | .83 | 5,331 | .74 | 1,432 | 1.09 | 169 | .63 | | | 2 by 2 | 28 | 189 | 46.2 | 26.2 | 4,274 | 1.00 | 7,251 | 1.00 | 1,310 | 1.00 | 269 | 1.00 | | Loblolly pine | 8 by 16 | 180 | 17 | 15.8 | 6.1 | 3,094 | .75 | 5,394 | .69 | 1,406 | .98 | 383 | 1.44 | | | 5 by 12 | 180 | 94 | 60.9 | 5.9 | 3,030 | .74 | 5,028 | .64 | 1,383 | .96 | 221 | .83 | | | 2 by 2 | 30 | 44 | 70.9 | 5.4 | 4,100 | 1.00 | 7,870 | 1.00 | 1,440 | 1.00 | 265 | 1.00 | | Tamarack | 6 by 12 | 162 | 15 | 57.6 | 16.6 | 2,914 | .75 | 4,500 | .66 | 1,202 | 1.05 | 255 | 1.11 | | | 4 by 10 | 162 | 15 | 43.5 | 11.4 | 2,712 | .70 | 4,611 | .68 | 1,238 | 1.08 | 209 | .91 | | | 2 by 2 | 30 | 82 | 38.8 | 14.0 | 3,875 | 1.00 | 6,820 | 1.00 | 1,141 | 1.00 | 229 | 1.00 | | Western hemlock | 8 by 16 | 180 | 39 | 42.5 | 15.6 | 3,516 | .80 | 5,296 | .73 | 1,445 | 1.01 | 261 | .92 | | | 2 by 2 | 28 | 52 | 51.8 | 12.1 | 4.406 | 1.00 | 7,294 | 1.00 | 1,428 | 1.00 | 284 | 1.00 | | Redwood | 8 by 16 | 180 | 14 | 86.5 | 19.9 | 3,734 | .79 | 4,492 | .64 | 1,016 | .96 | 300 | 1.21 | | | 6 by 12 | 180 | 14 | 87.3 | 17.8 | 3,787 | .80 | 4,451 | .64 | 1,068 | 1.00 | 224 | .90 | | | 7 by 9 | 180 | 14 | 79.8 | 16.7 | 4,412 | .93 | 5,279 | .76 | 1,324 | 1.25 | 199 | .80 | | | 3 by 14 | 180 | 13 | 86.1 | 23.7 | 3,506 | .74 | 4,364 | .62 | 947 | .89 | 255 | 1.03 | | | 2 by 12 | 180 | 12 | 70.9 | 18.6 | 3,100 | .65 | 3,753 | .54 | 1,052 | .99 | 187 | .75 | | | 2 by 10 | 180 | 13 | 55.8 | 20.0 | 3,285 | .69 | 4,079 | .58 | 1,107 | 1.04 | 169 | .68 | | | 2 by 8 | 180 | 13 | 63.8 | 21.5 | 2,989 | .63 | 4,063 | .58 | 1,141 | 1.08 | 134 | .54 | | | 2 by 2 | 28 | 157 | 75.5 | 19.1 | 4,750 | 1.00 | 6,980 | 1.00 | 1,061 | 1.00 | 248 | 1.00 | | Norway pine | 6 by 12 | 162 | 15 | 50.3 | 12.5 | 2,305 | .82 | 3,572 | .69 | 987 | 1.03 | 201 | 1.17 | | | 4 by 12 | 162 | 18 | 47.9 | 14.7 | 2,648 | .94 | 4,107 | .79 | 1,255 | 1.31 | 238 | 1.38 | | | 4 by 10 | 162 | 16 | 45.7 | 13.3 | 2,674 | .95 | 4,205 | .81 | 1,306 | 1.36 | 198 | 1.15 | | | 2 by 2 | 30 | 133 | 32.3 | 11.4 | 2,808 | 1.00 | 5,173 | 1.00 | 960 | 1.00 | 172 | 1.00 | | Red spruce | 2 by 10 | 144 | 14 | 32.5 | 21.9 | 2,394 | .66 | 3,566 | .60 | 1,180 | 1.02 | 181 | .80 | | | 2 by 2 | 26 | 60 | 37.3 | 21.3 | 3,627 | 1.00 | 5,900 | 1.00 | 1,157 | 1.00 | 227 | 1.00 | | White spruce | 2 by 10 | 144 | 16 | 40.7 | 9.3 | 2,239 | .72 | 3,288 | .63 | 1,081 | 1.08 | 166 | .83 | | | 2 by 2 | 26 | 83 | 58.3 | 10.2 | 3.090 | 1.00 | 5,185 | 1.00 | 998 | 1.00 | 199 | 1.00 | |-----------------------------------------------------------------------------------------------------------------------------------| | _Note.--Following is an explanation of the abbreviations used in the foregoing tables:_ | | F.S. at E.L. = Fiber stress at elastic limit. | | M. of E. = Modulus of elasticity. | | M. of R. = Modulus of rupture. | | Cr. str. at E.L. = Crushing strength at elastic limit. | | Cr. str. at max. ld. = Crushing strength at maximum load. | |-----------------------------------------------------------------------------------------------------------------------------------|

|-----------------------------------------------------------------------------------------------------------------------------------------------| | TABLE XIX TABLE XIX | |-----------------------------------------------------------------------------------------------------------------------------------------------| | COMPRESSION AND SHEAR TESTS ON GREEN MATERIAL | |-----------------------------------------------------------------------------------------------------------------------------------------------| | | Compression | Compression | Shear | | | parallel to grain | perpendicular to grain | | | |------------------------------------------------------+-------------------------------------------+--------------------------| | | | | | Cr. | | Cr. | | | | | Cr. | | | | | Species | | | Per | str. | M. of | str. | | | | Per | str. | | Per | | | | Size of | No. | cent | at | E. | at max. | Stress | | No. | cent | at max. | No. | cent | Shear | | | specimen | of | of | E. L. | per | ld.,. | area | Height | of | of | ld., | of | of | strength | | | | tests | mois- | per | square | per | | | tests | mois- | per | tests | mois- | | | | | | ture | square | inch | square | | | | ture | square | | ture | | | | | | | inch | | inch | | | | | inch | | | | |-----------------+----------+-------+-------+--------+--------+---------+--------+--------+-------+ ------+---------+-------+-------+----------| | | | | | | 1,000 | | | | | | | | | | | | Inches | | | Lbs. | lbs. | Lbs. | Inches | Inches | | | Lbs. | | | Lbs. | | | | | | | | | | | | | | | | | | Longleaf pine | 4 by 4 | 46 | 26.3 | 3,480 | | 4,800 | 4 by 4 | 4 | 22 | 25.3 | 568 | 44 | 21.8 | 973 | | | 2 by 2 | 14 | 34.7 | | | 4,400 | | | | | | | | | | Douglas fir | 6 by 6 | 515 | 30.7 | 2,780 | 1,181 | 3,500 | 4 by 8 | 16 | 259 | 30.3 | 570 | 531 | 29.7 | 765 | | | 5 by 6 | 170 | 30.9 | 2,720 | 2,123 | 3,490 | | | | | | | | | | | 2 by 2 | 902 | 29.8 | 3,500 | 1,925 | 4,030 | | | | | | | | | | Douglas fir | | | | | | | | | | | | | | | | (fire-killed) | 6 by 6 | 108 | 34.8 | 2,620 | 1,801 | 3,290 | 6 by 8 | 16 | 24 | 33.7 | 368 | 77 | 35.8 | 631 | | | 2 by 2 | 204 | 37.9 | | | 3,430 | | | | | | | | | | Shortleaf pine | 6 by 6 | 95 | 41.2 | 2,514 | 1,565 | 3,436 | 5 by 8 | 16 | 12 | 37.7 | 361 | 179 | 47.0 | 704 | | | 5 by 8 | 23 | 43.5 | 2,241 | 1,529 | 3,423 | 5 by 8 | 14 | 12 | 42.8 | 366 | | | | | | 2 by 2 | 281 | 51.4 | | | 3,570 | 5 by 8 | 12 | 24 | 53.0 | 325 | | | | | | | | | | | | 5 by 5 | 8 | 24 | 47.0 | 344 | | | | | | | | | | | | 2 by 2 | 2 | 277 | 48.5 | 400 | | | | | Western larch | 6 by 6 | 107 | 49.1 | 2,675 | 1,575 | 3,510 | 6 by 8 | 16 | 22 | 43.6 | 417 | 179 | 40.7 | 700 | | | 2 by 2 | 491 | 50.6 | 3,026 | 1,545 | 3,696 | 6 by 8 | 12 | 20 | 40.2 | 416 | | | | | | | | | | | | 4 by 6 | 6 | 53 | 52.8 | 478 | | | | | | | | | | | | 4 by 4 | 4 | 30 | 50.4 | 472 | | | | | Loblolly pine | 8 by 8 | 14 | 63.4 | 1,560 | 365 | 2,140 | 8 by 4 | 8 | 16 | 67.2 | 392 | 121 | 83.2 | 630 | | | 4 by 8 | 18 | 60.0 | 2,430 | 691 | 3,560 | 4 by 4 | 8 | 38 | 44.6 | 546 | | | | | | 2 by 2 | 53 | 74.0 | | | 3,240 | | | | | | | | | | Tamarack | 6 by 7 | 4 | 49.9 | 2,332 | 1,432 | 3,032 | | | | | | 24 | 39.2 | 668 | | | 4 by 7 | 6 | 27.7 | 2,444 | 1,334 | 3,360 | | | | | | | | | | | 2 by 2 | 165 | 36.8 | | | 3,190 | | | | | | | | | | Western hemlock | 6 by 6 | 82 | 46.6 | 2,905 | 1,617 | 3,355 | 6 by 4 | 6 | 30 | 48.7 | 434 | 54 | 65.7 | 630 | | | 2 by 2 | 131 | 55.6 | 2,938 | 1,737 | 3,392 | | | | | | | | | | Redwood | 6 by 6 | 34 | 83.6 | 3,194 | 1,240 | 3,882 | 6 by 8 | 16 | 13 | 86.7 | 473 | 148 | 84.2 | 742 | | | 2 by 2 | 143 | 36.8 | 3,490 | 1,222 | 3,980 | 6 by 6 | 12 | 14 | 83.0 | 424 | | | | | | | | | | | | 6 by 7 | 9 | 13 | 74.7 | 477 | | | | | | | | | | | | 6 by 3 | 14 | 13 | 75.6 | 411 | | | | | | | | | | | | 6 by 2 | 12 | 12 | 66.5 | 430 | | | | | | | | | | | | 6 by 2 | 10 | 11 | 55.0 | 423 | | | | | | | | | | | | 6 by 2 | 8 | 12 | 56.7 | 396 | | | | | | | | | | | | 2 by 2 | 2 | 186 | 75.5 | 569 | | | | | Norway pine | 6 by 7 | 5 | 29.0 | 1,928 | 905 | 2,404 | | | | | | 20 | 26.7 | 589 | | | 4 by 7 | 8 | 28.4 | 2,154 | 1,063 | 2,652 | | | | | | | | | | | 2 by 2 | 178 | 26.8 | | | 2,504 | | | | | | | | | | Red spruce | 2 by 2 | 58 | 35.4 | | | 2,750 | 2 by 2 | 2 | 43 | 31.8 | 310 | 30 | 32.0 | 758 | | White spruce | 2 by 2 | 84 | 61.0 | | | 2,370 | 2 by 2 | 2 | 46 | 50.4 | 270 | 40 | 58.0 | 651 | |-----------------------------------------------------------------------------------------------------------------------------------------------| | _Note.--Following is an explanation of the abbreviations used in the foregoing tables:_ | | F.S. at E.L. = Fiber stress at elastic limit. | | M. of E. = Modulus of elasticity. | | M. of R. = Modulus of rupture. | | Cr. str. at E.L. = Crushing strength at elastic limit. | | Cr. str. at max. ld. = Crushing strength at maximum load. | |-----------------------------------------------------------------------------------------------------------------------------------------------|

|-----------------------------------------------------------------------------------------------------------------------------------| | TABLE XX TABLE XX | |-----------------------------------------------------------------------------------------------------------------------------------| | BENDING TESTS ON AIR-SEASONED MATERIAL | |-----------------------------------------------------------------------------------------------------------------------------------| | | Sizes | | | | F.S. at E.L. | M. of R. | M. of E. | Calculated | | |-----------------| Num- | Per | Rings | | | | shear | | Species | | | ber | cent | per |-----------------+-----------------+-----------------+-----------------| | | Cross | Span | of | mois- | inch | Average | Ratio | Average | Ratio | Average | Ratio | Average | Ratio | | | Section | | tests | ture | | per sq. | to 2" | per sq. | to 2" | per sq. | to 2" | per sq. | to 2" | | | | | | | | inch | by 2" | inch | by 2" | inch | by 2" | inch | by 2" | |-----------------+----------+------+-------+-------+-------+---------+-------+---------+-------+---------+-------+---------+-------| | | | | | | | | | | | 1,000 | | | | | | Inches | Ins. | | | | Lbs. | | Lbs. | | lbs. | | Lbs. | | | | | | | | | | | | | | | | | | Longleaf pine | 8 by 16 | 180 | 5 | 22.2 | 16.0 | 3,390 | 0.50 | 4,274 | 0.37 | 1,747 | 1.00 | 288 | 0.75 | | | 6 by 16 | 132 | 1 | 23.4 | 17.1 | 3,470 | .51 | 6,610 | .57 | 1,501 | .86 | 388 | 1.01 | | | 6 by 10 | 177 | 2 | 19.0 | 8.8 | 4,560 | .68 | 7,880 | .68 | 1,722 | .99 | 214 | .56 | | | 4 by 11 | 180 | 1 | 18.4 | 23.9 | 3,078 | .46 | 8,000 | .69 | 1,660 | .95 | 251 | .66 | | | 6 by 8 | 177 | 6 | 20.0 | 13.7 | 4,227 | .63 | 8,196 | .71 | 1,634 | .94 | 177 | .46 | | | 2 by 2 | 30 | 17 | 15.9 | 13.9 | 6,750 | 1.00 | 11,520 | 1.00 | 1,740 | 1.00 | 383 | 1.00 | | Douglas fir | 8 by 16 | 180 | 91 | 20.8 | 13.1 | 4,563 | .68 | 6,372 | .61 | 1,549 | .91 | 269 | .64 | | | 5 by 8 | 180 | 30 | 14.9 | 12.2 | 5,065 | .76 | 6,777 | .65 | 1,853 | 1.09 | 218 | .52 | | | 2 by 2 | 24 | 211 | 19.0 | 16.4 | 6,686 | 1.00 | 10,378 | 1.00 | 1,695 | 1.00 | 419 | 1.00 | | Shortleaf pine | 8 by 16 | 180 | 3 | 17.0 | 12.3 | 4,220 | .54 | 6,030 | .50 | 1,517 | .85 | 398 | .98 | | | 8 by 14 | 180 | 3 | 16.0 | 12.3 | 4,253 | .55 | 5,347 | .44 | 1,757 | .98 | 307 | .76 | | | 8 by 12 | 180 | 7 | 16.0 | 12.4 | 5,051 | .65 | 7,331 | .60 | 1,803 | 1.01 | 361 | .89 | | | 5 by 8 | 180 | 6 | 12.2 | 22.5 | 7,123 | .92 | 9,373 | .77 | 1,985 | 1.11 | 301 | .74 | | | 2 by 2 | 30 | 67 | 14.2 | 13.7 | 7,780 | 1.00 | 12,120 | 1.00 | 1,792 | 1.00 | 404 | 1.00 | | Western larch | 8 by 16 | 180 | 23 | 18.3 | 21.9 | 3,343 | .57 | 5,440 | .53 | 1,409 | .90 | 349 | .96 | | | 8 by 12 | 180 | 29 | 17.8 | 23.4 | 3,631 | .62 | 6,186 | .60 | 1,549 | .99 | 295 | .81 | | | 5 by 8 | 180 | 10 | 13.6 | 27.6 | 4,730 | .80 | 7,258 | .71 | 1,620 | 1.04 | 221 | .61 | | | 2 by 2 | 30 | 240 | 16.1 | 26.8 | 5,880 | 1.00 | 10,254 | 1.00 | 1,564 | 1.00 | 364 | 1.00 | | Loblolly pine | 8 by 16 | 180 | 14 | 20.5 | 7.4 | 4,195 | .81 | 6,734 | .72 | 1,619 | 1.10 | 462 | 1.45 | | | 6 by 16 | 126 | 4 | 20.2 | 5.0 | 2,432 | .47 | 4,295 | .46 | 1,324 | .90 | 266 | .84 | | | 6 by 10 | 174 | 3 | 21.3 | 4.7 | 3,100 | .60 | 6,167 | .66 | 1,449 | .99 | 173 | .54 | | | 4 by 12 | 174 | 4 | 19.8 | 4.7 | 2,713 | .52 | 5,745 | .61 | 1,249 | .85 | 185 | .58 | | | 8 by 8 | 180 | 9 | 22.9 | 4.9 | 2,903 | .56 | 4,557 | .48 | 1,136 | .77 | 93 | .29 | | | 6 by 7 | 144 | 2 | 21.1 | 5.0 | 2,990 | .58 | 4,968 | .53 | 1,286 | .88 | 116 | .36 | | | 4 by 8 | 132 | 8 | 19.5 | 9.1 | 3,384 | .65 | 6,194 | .66 | 1,200 | .82 | 196 | .62 | | | 2 by 2 | 30 | 123 | 17.6 | 6.6 | 5,170 | 1.00 | 9,400 | 1.00 | 1,467 | 1.00 | 318 | 1.00 | | Tamarack | 6 by 12 | 162 | 5 | 23.0 | 15.1 | 3,434 | .45 | 5,640 | .43 | 1,330 | .82 | 318 | .75 | | | 4 by 10 | 162 | 4 | 14.4 | 9.7 | 4,100 | .54 | 5,320 | .41 | 1,386 | .84 | 252 | .59 | | | 2 by 2 | 30 | 47 | 11.3 | 16.2 | 7,630 | 1.00 | 13,080 | 1.00 | 1,620 | 1.00 | 425 | 1.00 | | Western hemlock | 8 by 16 | 180 | 44 | 17.7 | 17.8 | 4,398 | .69 | 6,420 | .62 | 1,737 | 1.04 | 406 | 1.06 | | | 2 by 2 | 28 | 311 | 17.9 | 19.4 | 6,333 | 1.00 | 10,369 | 1.00 | 1,666 | 1.00 | 382 | 1.00 | | Redwood | 8 by 16 | 180 | 6 | 26.3 | 22.4 | 3,797 | .79 | 4,428 | .57 | 1,107 | .96 | 294 | 1.05 | | | 6 by 12 | 180 | 6 | 16.1 | 17.7 | 3,175 | .66 | 3,353 | .43 | 728 | .64 | 167 | .60 | | | 7 by 9 | 180 | 6 | 15.9 | 15.2 | 3,280 | .69 | 4,002 | .51 | 1,104 | .96 | 147 | .53 | | | 3 by 14 | 180 | 6 | 13.1 | 24.4 | | | 5,033 | .64 | | | 291 | 1.04 | | | 2 by 12 | 180 | 5 | 13.8 | 14.4 | 3,928 | .82 | 5,336 | .68 | 1,249 | 1.09 | 260 | .93 | | | 2 by 10 | 180 | 5 | 13.8 | 24.8 | 3,757 | .79 | 4,606 | .59 | 1,198 | 1.05 | 186 | .67 | | | 2 by 8 | 180 | 6 | 13.7 | 20.7 | 4,314 | .90 | 5,050 | .65 | 1,313 | 1.15 | 166 | .60 | | | 2 by 2 | 28 | 122 | 15.2 | 18.8 | 4,777 | 1.00 | 7,798 | 1.00 | 1,146 | 1.00 | 279 | 1.00 | | Norway pine | 6 by 12 | 162 | 5 | 16.7 | 8.1 | 2,968 | .56 | 5,204 | .61 | 1,123 | .97 | 286 | 1.02 | | | 4 by 10 | 162 | 5 | 13.7 | 12.0 | 5,170 | .98 | 6,904 | .82 | 1,712 | 1.48 | 317 | 1.13 | | | 2 by 2 | 30 | 60 | 14.9 | 11.2 | 5,280 | 1.00 | 8,470 | 1.00 | 1,158 | 1.00 | 281 | 1.00 | |-----------------------------------------------------------------------------------------------------------------------------------| | _Note.--Following is an explanation of the abbreviations used in the foregoing tables:_ | | F.S. at E.L. = Fiber stress at elastic limit. | | M. of E. = Modulus of elasticity. | | M. of R. = Modulus of rupture. | | Cr. str. at E.L. = Crushing strength at elastic limit. | | Cr. str. at max. ld. = Crushing strength at maximum load. | |-----------------------------------------------------------------------------------------------------------------------------------|

|-----------------------------------------------------------------------------------------------------------------------------------------------| | TABLE XXI TABLE XXI | |-----------------------------------------------------------------------------------------------------------------------------------------------| | COMPRESSION AND SHEAR TESTS ON AIR-SEASONED MATERIAL | |-----------------------------------------------------------------------------------------------------------------------------------------------| | | Compression | Compression | Shear | | | parallel to grain | perpendicular to grain | | | |------------------------------------------------------+-------------------------------------------+--------------------------| | | | | | Cr. | | Cr. | | | | | Cr. | | | | | Species | | | Per | str. | M. of | str. | | | | Per | str. | | Per | | | | Size of | No. | cent | at | E. | at max. | Stress | | No. | cent | at max. | No. | cent | Shear | | | specimen | of | of | E. L. | per | ld.,. | area | Height | of | of | ld., | of | of | strength | | | | tests | mois- | per | square | per | | | tests | mois- | per | tests | mois- | | | | | | ture | square | inch | square | | | | ture | square | | ture | | | | | | | inch | | inch | | | | | inch | | | | |-----------------+----------+-------+-------+--------+--------+---------+--------+--------+-------+ ------+---------+-------+-------+----------| | | | | | | 1,000 | | | | | | | | | | | | Inches | | | Lbs. | lbs. | Lbs. | Inches | Inches | | | Lbs. | | | Lbs. | | | | | | | | | | | | | | | | | | Longleaf pine | 4 by 5 | 46 | 26.3 | 3,480 | | 4,800 | 4 by 5 | 4 | 22 | 25.1 | 572 | 52 | 20.2 | 984 | | Douglas fir | 6 by 6 | 259 | 20.3 | 3,271 | 1,038 | 4,258 | 4 by 8 | 16 | 44 | 20.8 | 732 | 465 | 22.1 | 822 | | | 2 by 2 | 247 | 18.7 | 3,842 | 1,084 | 5,002 | 4 by 8 | 10 | 32 | 18.1 | 584 | | | | | | | | | | | | 4 by 4 | 8 | 51 | 20.2 | 638 | | | | | | | | | | | | 4 by 4 | 6 | 49 | 24.0 | 613 | | | | | | | | | | | | 4 by 4 | 4 | 29 | 24.8 | 603 | | | | | Shortleaf pine | 6 by 6 | 29 | 15.7 | 4,070 | 1,951 | 6,030 | 8 by 5 | 16 | 4 | 17.8 | 725 | 85 | | 1,135 | | | 2 by 2 | 57 | 14.2 | | | 6,380 | 8 by 5 | 14 | 3 | 16.3 | 757 | | | | | | | | | | | | 8 by 5 | 12 | 5 | 15.1 | 730 | | | | | | | | | | | | 5 by 5 | 8 | 6 | 13.0 | 918 | | | | | | | | | | | | 2 by 2 | 2 | 57 | 13.9 | 926 | | | | | Western larch | 6 by 6 | 112 | 16.0 | | | 5,445 | 8 by 6 | 16 | 17 | 18.8 | 491 | 193 | 15.0 | 905 | | | 4 by 4 | 81 | 14.7 | | | 6,161 | 8 by 6 | 12 | 18 | 17.6 | 526 | | | | | | 2 by 2 | 270 | 14.8 | | | 5,934 | 5 by 4 | 8 | 22 | 13.3 | 735 | | | | | Loblolly pine | 6 by 6 | 23 | | 3,357 | 1,693 | 5,005 | 8 by 5 | 16 | 12 | 19.8 | 602 | 156 | 11.3 | 1,115 | | | 5 by 5 | 10 | 22.4 | 2,217 | 545 | 2,950 | 8 by 5 | 8 | 7 | 22.9 | 679 | | | | | | 4 by 8 | 8 | 19.4 | 3,010 | 633 | 3,920 | 4 by 5 | 8 | 8 | 19.5 | 715 | | | | | | 2 by 2 | 69 | | | | 5,547 | | | | | | | | | | Tamarack | 6 by 7 | 3 | 15.7 | 2,257 | 1,042 | 3,323 | 2 by 2 | 2 | 57 | 16.2 | 697 | 60 | 14.0 | 879 | | | 4 by 7 | 3 | 13.6 | 3,780 | 1,301 | 4,823 | | | | | | | | | | | 4 by 4 | 57 | 14.9 | 3,386 | 1,353 | 4,346 | | | | | | | | | | | 2 by 2 | 66 | 14.6 | | | 4,790 | | | | | | | | | | Western hemlock | 6 by 6 | 102 | 18.6 | 4,840 | 2,140 | 5,814 | 7 by 6 | 15 | 25 | 18.2 | 514 | 131 | 17.7 | 924 | | | 2 by 2 | 463 | 17.0 | 4,560 | 1,923 | 5,403 | 6 by 6 | 6 | 26 | 16.8 | 431 | | | | | | | | | | | | 4 by 4 | 4 | 6 | 15.9 | 488 | | | | | Redwood | 6 by 6 | 18 | 16.9 | | | 4,276 | 8 by 6 | 16 | 5 | 25.4 | 548 | 95 | 12.4 | 671 | | | 2 by 2 | 115 | 14.6 | | | 5,119 | 6 by 6 | 12 | 6 | 14.7 | 610 | | | | | | | | | | | | 7 by 6 | 9 | 5 | 14.8 | 500 | | | | | | | | | | | | 3 by 6 | 14 | 2 | 12.6 | 470 | | | | | | | | | | | | 2 by 6 | 12 | 2 | 16.2 | 498 | | | | | | | | | | | | 2 by 6 | 10 | 4 | 14.3 | 511 | | | | | | | | | | | | 2 by 6 | 8 | 2 | 13.2 | 429 | | | | | | | | | | | | 2 by 2 | 2 | 145 | 13.8 | 564 | | | | | Norway pine | 6 by 7 | 4 | 15.2 | 2,670 | 1,182 | 4,212 | 2 by 2 | 2 | 36 | 10.0 | 924 | 44 | 11.9 | 1,145 | | | 4 by 7 | 2 | 22.2 | 3,275 | 1,724 | 4,575 | | | | | | | | | | | 4 by 4 | 55 | 16.6 | 3,048 | 1,367 | 4,217 | | | | | | | | | | | 2 by 2 | 44 | 11.2 | | | 7,550 | | | | | | | | | |-----------------------------------------------------------------------------------------------------------------------------------------------| | _Note.--Following is an explanation of the abbreviations used in the foregoing tables:_ | | F.S. at E.L. = Fiber stress at elastic limit. | | M. of E. = Modulus of elasticity. | | M. of R. = Modulus of rupture. | | Cr. str. at E.L. = Crushing strength at elastic limit. | | Cr. str. at max. ld. = Crushing strength at maximum load. | |-----------------------------------------------------------------------------------------------------------------------------------------------|

|----------------------------------------------------------------------------------------------------------------------------------------------------------------------------------| | TABLE XXII TABLE XXII | |----------------------------------------------------------------------------------------------------------------------------------------------------------------------------------| | [b]WORKING UNIT-STRESSES FOR STRUCTURAL TIMBER[c] | | EXPRESSED IN POUNDS PER SQUARE INCH | | (From Manual of the American Railway Engineering Assn., 1911, p. 153) | |----------------------------------------------------------------------------------------------------------------------------------------------------------------------------------| | NOTE.--The working unit-stresses given in the table are intended for railroad bridges and trestles. For highway bridges and trestles the unit-stresses may be increased | | twenty-five (25) per cent. For buildings and similar structures, in which the timber is protected from the weather and practically free from impact, the unit-stresses may be | | increased fifty (50) per cent. To compute the deflection of a beam under long-continued loading instead of that when the load is first applied, only fifty (50) per cent of the | | corresponding modulus of elasticity given in the table is to be employed. | |----------------------------------------------------------------------------------------------------------------------------------------------------------------------------------| | | BENDING | SHEARING | COMPRESSION | | | |---------------------------------+-----------------------------------------+-------------------------------------------------------------------------| Ratio | | | Extreme | Modulus of | Parallel to | Longitudinal | Perpendicular | Parallel to | For | Formulæ for | of | | | fibre | elasticity | the grain | shear in | to the grain | the grain | columns | working stress in | length | | KIND OF | stress | | | beams | | | under 15 | long columns over | of | | TIMBER |--------------------+------------+--------------------+--------------------+--------------------+--------------------| diameters | 15 diameters | stringer | | | Average | Working | | Average | Working | Elastic | Working | Elastic | Working | Average | Working | working | | to | | | ultimate | stress | Average | ultimate | stress | limit | stress | limit | stress | ultimate | stress | stress | | depth | |-----------------+----------+---------+------------+----------+---------+----------+---------+----------+---------+----------+---------+-----------+-------------------+----------| | Douglas fir | 6100 | 1200 | 1,510,000 | 690 | 170 | 270 | 110 | 630 | 310 | 3600 | 1200 | 900 | 1200(1-_l_/60_d_) | 10 | |-----------------+----------+---------+------------+----------+---------+----------+---------+----------+---------+----------+---------+-----------+-------------------+----------| | Longleaf pine | 6500 | 1300 | 1,610,000 | 720 | 180 | 300 | 120 | 520 | 260 | 3800 | 1300 | 980 | 1300(1-_l_/60_d_) | 10 | |-----------------+----------+---------+------------+----------+---------+----------+---------+----------+---------+----------+---------+-----------+-------------------+----------| | Shortleaf pine | 5600 | 1100 | 1,480,000 | 710 | 170 | 330 | 130 | 340 | 170 | 3400 | 1100 | 830 | 1100(1-_l_/60_d_) | 10 | |-----------------+----------+---------+------------+----------+---------+----------+---------+----------+---------+----------+---------+-----------+-------------------+----------| | White pine | 4400 | 900 | 1,130,000 | 400 | 100 | 180 | 70 | 290 | 150 | 3000 | 1000 | 750 | 1000(1-_l_/60_d_) | 10 | |-----------------+----------+---------+------------+----------+---------+----------+---------+----------+---------+----------+---------+-----------+-------------------+----------| | Spruce | 4800 | 1000 | 1,310,000 | 600 | 150 | 170 | 70 | 370 | 180 | 3200 | 1100 | 830 | 1100(1-_l_/60_d_) | | |-----------------+----------+---------+------------+----------+---------+----------+---------+----------+---------+----------+---------+-----------+-------------------+----------| | Norway pine | 4200 | 800 | 1,190,000 | 590[d] | 130 | 250 | 100 | | 150 | 2600[d] | 800 | 600 | 800(1-_l_/60_d_) | | |-----------------+----------+---------+------------+----------+---------+----------+---------+----------+---------+----------+---------+-----------+-------------------+----------| | Tamarack | 4600 | 900 | 1,220,000 | 670 | 170 | 260 | 100 | | 220 | 3200[d] | 1000 | 750 | 1000(1-_l_/60_d_) | | |-----------------+----------+---------+------------+----------+---------+----------+---------+----------+---------+----------+---------+-----------+-------------------+----------| | Western hemlock | 5800 | 1100 | 1,480,000 | 630 | 160 | 270[d] | 100 | 440 | 220 | 3500 | 1200 | 900 | 1200(1-_l_/60_d_) | | |-----------------+----------+---------+------------+----------+---------+----------+---------+----------+---------+----------+---------+-----------+-------------------+----------| | Redwood | 5000 | 900 | 800,000 | 300 | 80 | | | 400 | 150 | 3300 | 900 | 680 | 900(1-_l_/60_d_) | | |-----------------+----------+---------+------------+----------+---------+----------+---------+----------+---------+----------+---------+-----------+-------------------+----------| | Bald cypress | 4800 | 900 | 1,150,000 | 500 | 120 | | | 340 | 170 | 3900 | 1100 | 830 | 1100(1-_l_/60_d_) | | |-----------------+----------+---------+------------+----------+---------+----------+---------+----------+---------+----------+---------+-----------+-------------------+----------| | Red cedar | 4200 | 800 | 800,000 | | | | | 470 | 230 | 2800 | 900 | 680 | 900(1-_l_/60_d_) | | |-----------------+----------+---------+------------+----------+---------+----------+---------+----------+---------+----------+---------+-----------+-------------------+----------| | White oak | 5700 | 1100 | 1,150,000 | 840 | 210 | 270 | 110 | 920 | 450 | 3500 | 1300 | 980 | 1300(1-_l_/60_d_) | 12 | |----------------------------------------------------------------------------------------------------------------------------------------------------------------------------------| | These unit-stresses are for a green condition of timber and are _l_ = Length in inches. | | to be used without increasing the live load stresses for impact. _d_ = Least side in inches. | |----------------------------------------------------------------------------------------------------------------------------------------------------------------------------------| |[Footnote b: Adopted, Vol. 1909, pp. 537, 564, 609-611.] | |[Footnote c: Green timber in exposed work.] | |[Footnote d: Partially air-dry] | |----------------------------------------------------------------------------------------------------------------------------------------------------------------------------------|

BIBLIOGRAPHY

## Part I : Some general works on mechanics, materials of

construction, and testing of materials.

## Part II : Publications and articles on the mechanical properties

of wood, and timber testing.

## Part III : Publications of the U.S. Government on the mechanical

properties of wood, and timber testing.

##