Part 9

On leaving Messrs. Pommery's we retrace our steps down the Avenue Gerbert, bordered on either side with rows of plane-trees, until we reach the treeless Avenue de Sillery, where Messrs. de Saint Marceaux and Co.'s new and capacious establishment is installed. The principal block of building is flanked by two advanced wings inclosing a garden-court, set off with flowers and shrubs, and from the centre of which rises a circular shaft, covered in with glass, admitting light and air to the cellars below. In the building to the left the wine is received on its arrival from the vineyard, and here are ranged hundreds of casks replete with the choice _crûs_ of Verzenay, Ay, Cramant, and Bouzy, while some thousands of bottles ready for labelling are stocked in massive piles at the end of the packing-hall in the corresponding wing of the establishment. Here, too, a tribe of workpeople are arraying the bottles with gold and silver headdresses and robing them in pink paper, while others are filling, securing, marking, and addressing the cases or baskets to Hong-Kong, San Francisco, Yokohama, Bombay, London, New York, St. Petersburg, Berlin, or Paris.

The wine in cask, stored in the left-hand wing, after having been duly blended in a vast vat holding over 2,400 gallons, is drawn off into bottles, which are then lowered down a shaft to the second tier of cellars by means of an endless chain, on to which the baskets of bottles are swiftly hooked. The workman engaged in this duty, in order to prevent his falling down the shaft, has a leather belt strapped round his waist, by means of which he is secured to an adjoining iron column. We descend into the lower cellars down a flight of ninety-three broad steps--a depth equal to the height of an ordinary six-storied house--and find no less than four-and-twenty galleries excavated in the chalk, without any masonry supports, and containing upwards of a million bottles of champagne. The length of these galleries varies, but they are of a uniform breadth, allowing either a couple of racks with wine _sur pointe_, or stacks of bottles, in four rows on either side, with an ample passage down the centre.

The upper range of cellars comprises two large arched galleries of considerable breadth, one of which contains wine in wood and wine _sur pointe_, while the other is stocked with bottles of wine heads downward, ready to be delivered into the hands of the _dégorgeur_.

MM. de St. Marceaux and Co. have the honour of supplying the King of the Belgians, the President of the French Republic, and several German potentates, with an exceedingly delicate champagne known as the Royal St. Marceaux. The same wine is popular in Russia and other parts of Europe, just as the Dry Royal of the firm is much esteemed in the United States. The brand of the house most appreciated in this country is its Carte d'Or, a very dry wine which, in conjunction with the firm's Extra Quality, secured the first place at a recent champagne competition in England.

In the neighbourhood of the Pommery and de St. Marceaux establishments numerous other champagne manufacturers have their cellars formed from the abandoned quarries so numerous on this side of the city. Of some of these firms we have already spoken, but there remain to be mentioned Messrs. Kunklemann and Co., Ruinart père et fils, George Goulet, Jules Champion, Théophile Roederer, &c. The cellars of the three last-named are immediately outside the Porte Dieu-Lumière, near which is a house with a curious bas-relief on its face, the subject of which has been a source of much perplexity to local antiquaries.

[Illustration: BAS-RELIEF NEAR THE PORTE DIEU-LUMIÈRE.]

[Illustration: JEAN REMI MOET.]

X.--EPERNAY CHAMPAGNE ESTABLISHMENTS.

Early Records of the Moët Family at Reims and Epernay-- Jean Remi Moët Founder of the Commerce in Champagne Wines-- Extracts from the Old Account-Books of the Moëts-- First Sales of Sparkling Wines-- Sales to England in 1788-- "Milords" Farnham and Findlater-- Jean Remi Moët receives the Emperor Napoleon, Josephine, and the King of Westphalia-- The Firm of Moët and Chandon Constituted-- Their Establishment in the Rue du Commerce-- Delivering and Washing the New Bottles-- The Numerous Vineyards and Vendangeoirs of the Firm-- Making the Cuvée in Vats of 12,000 Gallons-- The Bottling of the Wine by 200 Hands-- A Hundred Thousand Bottles Completed Daily-- 20,000 Francs' worth of Broken Glass in Two Years-- A Subterranean City, with miles of Streets, Cross Roads, Open Spaces, Tramways, and Stations-- The Ancient Entrance to these Vaults-- Tablet Commemorative of the Visit of Napoleon I.-- Millions of Bottles of Champagne in Piles and Racks-- The Original Vaults known as Siberia-- Scene in the Packing Hall-- Messrs. Moët and Chandon's Large and Complete Staff-- Provision for Illness and Old Age-- Annual Fête Given by the Firm-- Their Famous "Star" Brand-- M. Perrier-Jouët, the lucky Grandson of a little Epernay Grocer-- His Offices and Cellars-- His Wine Classed according to its Deserts-- Messrs. Roussillon and Co.'s Establishment-- The Recognition accorded to their Wines-- Their Stock of Old Vintages-- The Extensive Establishment of Messrs. Pol Roger and Co.-- Their Large Stock of the Fine 1874 Vintage-- Preparations for the Tirage-- Their Vast Fireproof Cellier and its Admirable Temperature-- Their Lofty and Capacious Cellars of Two Stories.

Those magnates of the champagne trade, Messrs. Moët and Chandon, whose famous "star" brand is familiar in every part of the civilised globe, and whose half-score miles of cellars contain as many million bottles of champagne as there are millions of inhabitants in most of the secondary European states, have their head-quarters at Epernay in a spacious château--in that street of châteaux named the Rue du Commerce, but commonly known as the Faubourg de la Folie--which is approached through handsome iron gates, and has beautiful gardens in the rear extending in the direction of the River Marne. The existing firm dates from the year 1833, but the family of Moët--conjectured to have originally come from the Low Countries--had already been associated with the champagne wine trade for well-nigh a century previously. If the Moëts came from Holland they must have established themselves in the Champagne at a very early date, for the annals of Reims record that in the fifteenth century Jean and Nicolas Moët were _échevins_ of the city. A Moët was present in that capacity at the coronation of Charles VII. in 1429, when Joan of Arc stood erect by the principal altar of the cathedral with her sacred banner in her hand, and for having contributed to repulse an attempt on the part of the English to prevent the entrance of the Royal party into the city, the Moëts were subsequently ennobled by the same monarch. A mural tablet in the church of St. Remi records the death of D. G. Moët, Grand Prior, in 1554, and nine years later we find Nicol Moët claiming exemption at Epernay from the payment of _tailles_ on the ground of his being a noble. An old commercial book preserved in the family archives shows that in the year 1743--at the epoch when the rashness of the Duc de Grammont saved the English army under George II. from being cut to pieces at Dettingen--a descendant of the foregoing, one Claude Louis Nicolas Moët, who owned considerable vineyard property in the vicinity of Epernay, decided upon embarking in the wine trade. It is his son, however, Jean Remi Moët, born in 1758, who may be looked upon as the veritable founder of the present commerce in Champagne wines, which, thanks to his efforts, received a wonderful impulse, so that instead of the consumption of the vintages of the Marne being limited as heretofore to the privileged few, it spread all over the civilised world.

At Messrs. Moët and Chandon's we had the opportunity of inspecting some of the old account-books of the firm, and more particularly those recording the transactions of Jean Remi Moët and his father. The first sales of sparkling wine, on May 23rd, 1743, comprised 301 bottles of the vintage of 1741 to Pierre Joly, wine-merchant, _bon des douze chez le Roi_, whatever that may mean, at Paris; 120 bottles to Pierre Gabriel Baudoin, also _bon des douze_, at Paris; and a similar quantity to the Sieur Compoin, keeping the "hotellerie ditte la pestitte Escurie," Rue du Port Maillart, at Nantes in Brittany. The entry specifies that the wine for Nantes is to be left at Choisy-le-Roi, and taken by land to Orleans by the carters of that town, who are to be found at the Ecu d'Orléans, Porte St. Michel, Paris, the carriage as far as Choisy being 4 livres 10 deniers (about 4 francs) for the two half-baskets, and to Paris 3 livres 15 deniers the basket.

Between 1750 and '60, parcels of wine were despatched to Warsaw, Vienna, Berlin, Königsberg, Dantzig, Stettin, Brussels, and Amsterdam; but one found no mention of any sales to England till the year 1788, when the customers of the firm included "Milord" Farnham, of London, and Messrs. Felix Calvert and Sylvin, who had a couple of sample bottles sent to them, for which they were charged five shillings. In the same year Messrs. Carbonnell, Moody, and Walker (predecessors of the well-known existing firm of Carbonnell and Co.) wrote in French for two baskets, of ten dozens each, of _vin de champagne_ "of good body, not too charged with liqueur, but of excellent taste, and _not at all sparkling_!" while the Chevalier Colebrook, writing from Bath, requests that 72 bottles of champagne may be sent to his friend the Hon. John Butler, Molesworth Street, Dublin, "who if contented with the wine will become a good customer, he being rich, keeping a good house, and receiving many amateurs of _vin de champagne_." Shortly afterwards the chevalier himself receives 50 bottles of still wine, vintage 1783. In 1789 120 bottles of champagne, vintage 1788, are supplied to "Milord" Findlater, of London--an ancestor, no doubt, of the wine-merchants of the same name carrying on business to-day, and whom the Moëts in their simplicity dubbed a "Milord"--and in 1790 the customers of the house include Power and Michel, of 44, Lamb Street, London, and Manning, of the St. Alban Tavern, the latter of whom is supplied on March 30th with 130 bottles of champagne at three livres, or two "schillings," per bottle; while a month later Mr. Lockart, banker, of 36, Pall Mall, is debited with 360 bottles, vintage 1788, at three shillings.

[Illustration: WASHING BOTTLES AT MESSRS. MOËT & CHANDON'S, EPERNAY. (p. 105)]

In this same year M. Moët despatches a traveller to England named Jeanson, and his letters, some two hundred in number, are all preserved in the archives of the house. On the 17th May, 1790, he writes from London as follows:--"As yet I have only gone on preparatory and often useless errands. I have distributed samples of which I have no news. Patience is necessary, and I endeavour to provide myself with it. How the taste of this country has changed since ten years ago! Almost everywhere they ask for dry wine, but at the same time require it so vinous and so strong that there is scarcely any other than the wine of Sillery which can satisfy them.... To-morrow I dine five miles from here, at M. Macnamara's. We shall uncork four bottles of our wine, which will probably be all right." In May, 1792, Jean Remi Moët is married, and thenceforward assumes the full management of the house. On December 20 of the year following, when the Reign of Terror was fairly inaugurated, we find the accounts in the ledger opened to this or the other "citoyen." The orthodox Republican formula, however, did not long continue, and "sieur" and "monsieur" resumed their accustomed places, showing that Jean Remi Moët had no sympathy with the Jacobin faction of the day. In 1805 he became Mayor of Epernay, and between this time and the fall of the Empire received Napoleon several times at his residence, as well as the Empress Josephine and the King of Westphalia. The Emperor, after recapturing Reims from the Allies, came on to Epernay, on which occasion he presented M. Moët with the cross of the Legion of Honour. In 1830 the latter was arbitrarily dismissed from his mayoralty by Charles X., but was speedily reinstated by Louis Philippe, though he did not retain his office for long, his advanced age compelling him to retire from active life in the course of 1833. At this epoch the firm, which, since 1807 had been known as Moët and Co., was remodelled under the style of Moët and Chandon, the two partners being M. Victor Moët, son of the outgoing partner, and M. P. G. Chandon, the descendant of an old ennobled family of the Mâconnais, who had married M. Jean Remi Moët's eldest daughter. The descendants of these gentlemen are to-day at the head of the business, the partners being on the one hand M. Victor Moët-Romont and M. C. J. V. Auban Moët-Romont; and on the other, MM. Paul and Raoul Chandon de Briailles.

Facing Messrs. Moët and Chandon's offices at Epernay is a range of comparatively new buildings, with its white façade ornamented with the well-known monogram M. and C., surmounted by the familiar star. It is here that the business of blending and bottling the wine is carried on. Passing through the arched gateway access is obtained to a spacious courtyard, where carts laden with bottles are being expeditiously lightened of their fragile contents by the busy hands of numerous workmen. Another gateway on the left leads into the spacious bottle-washing room, which from the middle of May until the middle of July presents a scene of extraordinary animation. Bottle-washing apparatus, supplied by a steam-engine with 20,000 gallons of water per diem, are ranged in fifteen rows down the entire length of this hall, and nearly 200 women strive to excel each other in diligence and celerity in their management, a practised hand washing from 900 to 1,000 bottles in the course of the day. To the right of this _salle de rinçage_, as it is styled, bottles are stacked in their tens of thousands, and lads furnished with barrows, known as _diables_, hurry to and fro, conveying these to the washers, or removing the clean bottles to the adjacent courtyard, where they are allowed to drain, prior to being taken to the _salle de tirage_ or bottling room.

Before, however, the washing of bottles on this gigantic scale commences, the "marrying" or blending of the wine is accomplished in a vast apartment, 250 feet in length and 100 feet broad, during the early spring. The casks of newly-vintaged wine which have been stowed away during the winter months, in the extensive range of cellars hewn out of the chalk underlying Epernay, where they have slowly fermented, are mixed together in due proportions in huge vats, each holding upwards of 12,000 gallons. Some of this wine is the growth of Messrs. Moët and Chandon's own vineyards, of which they possess as many as 900 acres (giving constant employment to 800 labourers and vinedressers) at Ay, Avenay, Bouzy, Cramant, Champillon, Chouilly, Dizy, Epernay, Grauves, Hautvillers, Le Mesnil, Moussy, Pierry, Saran, St. Martin, Verzy, and Verzenay, and the average annual cost of cultivating which is about £40 per acre. At Ay the firm own 210 acres of vineyards; at Cramant and Chouilly, nearly 180 acres; at Verzy and Verzenay, 120 acres; at Pierry and Grauves, upwards of 100 acres; at Hautvillers, 90 acres; at Le Mesnil, 80 acres; at Epernay, nearly 60 acres; and at Bouzy, 55 acres. Messrs. Moët and Chandon, moreover, possess vendangeoirs, or pressing-houses, at Ay, Bouzy, Cramant, Epernay, Hautvillers, Le Mesnil, Pierry, Saran, and Verzenay, in which the large number of 40 presses are installed. At these vendangeoirs no less than 5,450 pièces of fine white wine, sufficient for 1,360,000 bottles of champagne, are annually made--that is, 1,200 pièces at Ay, 1,100 at Cramant and Saran, 800 at Verzy and Verzenay, and smaller quantities at the remaining establishments. All these establishments have their celliers and their cellars, together with cottages for the accommodation of the numerous vinedressers in the employment of the firm.

[Illustration: MESSRS. MOËT & CHANDON'S VENDANGEOIR AT BOUZY. (p. 106)]

[Illustration: BOTTLING CHAMPAGNE AT MESSRS. MOËT & CHANDON'S, EPERNAY. (p. 107)]

Extensive as are the vineyards owned by Messrs. Moët and Chandon, the yield from them is utterly inadequate to the enormous demand which the great Epernay firm are annually called upon to supply, and large purchases have to be made by their agents from the growers throughout the Champagne. The wine thus secured, as well as that grown by the firm, is duly mixed together in such proportions as will ensure lightness with the requisite vinosity, and fragrance combined with effervescence, a thorough amalgamation being effected by stirring up the wine with long poles provided with fan-shaped ends. If the vintage be indifferent in quality the firm have scores of huge tuns filled with the yield of more favoured seasons to fall back upon to ensure any deficiencies of character and flavour being supplied.

The casks of wine to be blended are raised from the cellars, half a dozen at a time, by means of a lift provided with an endless chain, and worked by the steam-engine of which we have already spoken. They are emptied, through traps in the floor of the room above, into the huge vats which, standing upon a raised platform, reach almost to the ceiling. From these vats the fluid is allowed to flow through hose into rows of casks stationed below. Before being bottled the wine reposes for a certain time, is next duly racked and again blended, and is eventually conveyed through silver-plated pipes into oblong reservoirs, each fitted with a dozen syphon-taps, so arranged that directly the bottle slipped on to one of them becomes full the wine ceases to flow.

[Illustration]

Upwards of 200 workpeople are employed in the _salle de tirage_ at Messrs. Moët and Chandon's, which, while the operation of bottling is going on, presents a scene of bewildering activity. Men and lads are gathered round the syphon-taps briskly removing the bottles as they become filled, and supplanting them by empty ones. Other lads hasten to transport the filled bottles on trucks to the corkers, whose so-called "guillotine" machines send the corks home with a sudden thud. The corks being secured with _agrafes_ the bottles are placed in large flat baskets called _manettes_, and wheeled away on tracks, the quarts being deposited in the cellars by means of lifts, while the pints slide down an inclined plane by the aid of an endless chain, which raises the trucks with the empty baskets at the same time the full ones make their descent into the cellars. What with the incessant thud of the corking machines, the continual rolling of iron-wheeled trucks over the concrete floor, the rattling and creaking of the machinery working the lifts, the occasional sharp report of a bursting bottle, and the loudly-shouted orders of the foremen, who display the national partiality for making a noise to perfection, the din becomes at times all but unbearable. The number of bottles filled in the course of the day naturally varies, still Messrs. Moët and Chandon reckon that during the month of June a daily average of 100,000 are taken in the morning from the stacks in the _salle de rinçage_, washed, dried, filled, corked, wired, lowered into the cellars and carefully arranged in symmetrical order. This represents a total of two and a half million bottles during that month alone.

The bottles on being lowered into the cellars, either by means of the incline or the lifts, are placed in a horizontal position, and with their uppermost side daubed with white chalk, are stacked in layers from two to half-a-dozen bottles deep with narrow oak laths between. The stacks are usually about six or seven feet high and 100 feet and upwards in length. Whilst the wine is thus reposing in a temperature of about 55° Fahrenheit, fermentation sets in, and the ensuing month is one of much anxiety. Thanks, however, to the care bestowed, Messrs. Moët and Chandon's annual loss from bottles bursting rarely exceeds three per cent., though fifteen was once regarded as a respectable and satisfactory average. The broken glass is a perquisite of the workmen, the money arising from its sale, which at the last distribution amounted to no less than 20,000 francs, being divided amongst them every couple of years.

[Illustration]

The usual entrance to Messrs. Moët and Chandon's Epernay cellars--which, burrowed out in all directions, are of the aggregate length of nearly seven miles, and have usually between 11,000,000 and 12,000,000 bottles and 25,000 casks of wine stored therein--is through a wide and imposing portal, and down a long and broad flight of steps. It is, however, by the ancient and less imposing entrance, through which more than one crowned head has condescended to pass, that we set forth on our lengthened tour through these intricate underground galleries--this subterranean city with its miles of streets, crossroads, open spaces, tramways, and stations devoted solely to champagne. A gilt inscription on a black marble tablet testifies that "on the 26th July, 1807, Napoleon the Great, Emperor of the French, King of Italy, and Protector of the Confederation of the Rhine, honoured commerce by visiting the cellars of Jean Rémi Moët, Mayor of Epernay, President of the Canton, and Member of the General Council of the Department," within three weeks of the signature of the treaty of Tilsit. Passing down the flight of steep slippery steps traversed by the victor of Eylau and Jena, access is gained to the upper range of vaults, brilliantly illuminated by the glare of gas, or dimly lighted by the flickering flame of tallow-candles, upwards of 60,000lbs. of which are annually consumed. Here group after group of the small army of 350 workmen employed in these subterranean galleries are encountered engaged in the process of transforming the _vin brut_ into champagne. At Messrs. Moët and Chandon's the all-important operation of liqueuring the wine is effected by aid of machines of the latest construction, which regulate the quantity administered to the utmost nicety. The corks are branded by being pressed against steel dies heated by gas, by women who can turn out 3,000 per day apiece, the quantity of string used to secure them amounting to nearly ten tons in the course of the year.